CUT OFF MOST OF THE FAT:
Once I had some pork skin in hand, I was off to the chicharrone races. My first attempt was tasty but I wouldn’t call it a success. I left far too much of the fat on the skin, having read that it was fine to do so. This appealed to me in part because it eliminated the extra work of cutting the fat off the skin, but also because I thought it would be tastier.
It is not fine to do so, however, since when you go to fry the pork rinds, the fat puffs up into something resembling a pillow and floats with the pork skin on top. It’s like a little life jacket for each piece of pork skin, rescuing it from drowning in the hot oil. Your pork skin won’t sizzle and get all crispy, but instead become hard and impossible to chew and the only part you will be able to eat is the fatty pillow attached to the skin. Which is delicious, by the way.
CUT THE SKIN INTO PIECES:
It wasn’t until my third attempt that I nailed down the process and ended up with perfectly crispy chicharrones. You really do need to remove the majority of the fat from the skin, and it’s not as hard as it appears. Cutting the skin into long strips about 2 inches wide made the removal more manageable. I then scored the fat and the slid a sharp knife (really sharp knife, so get out that knife sharpener!) under the first piece of fat. Once that was removed, I could use that part of the skin to hold onto and slide my knife easily under the remaining pieces of fat (see photo below). From there, I could cut my strips of skin into 2 inch pieces.
SAVE THE FAT!
This leaves you with a lot of cubed fat and most recipes will tell you to discard it. Don’t you DARE! That is good stuff and super healthy if you’ve managed to procure some pasture-raised pork skin. You can do a number of things with it, including making sausage, rendering your own lard (healthy lard!) and even using it to fry the chicharrones themselves. In fact, many recipes I came across have you frying the chicharrones in lard and why not fry it in its own lard instead of the hydrogenated store bought variety? This last time, I cubed the fat and froze about half of it for future sausage making, and then rendered the rest and used it to fry the chicharrones. It wasn’t quite enough lard, so I added some cooking oil (grapeseed) to top it up.
DRY OUT THE SKINS:
When I started investigating making my own pork rinds, I saw any number of methods and some of them were quite laborious. Hours of boiling in water to render off the fat and soften the skin and then another hour of boiling in hot oil until they puff up and become crispy. I was beginning to think I really didn’t want to make them at all when I came across this recipe for Cuban Chicharrones. It offered me a choice of two methods, one of which meant I could turn on my oven at a low temperature for several hours and leave the skins to their own devices.
FRY THEM UP!
Once they were sufficiently dried, I could then fry them up to cracklin’ perfection. It worked beautifully and I wouldn’t make them any other way.
As for flavourings and seasonings, you have so many great choices. I’d say the best approach to adding flavour is to wait until the crispy skins come out of the hot fat, and then toss them immediately with any spices then. For now, I am just enjoying the flavour of the chicharrones all on their own, enhanced only be a little salt and pepper.
Homemade Chicharrones
Ingredients
- 3 to 5 lbs pork back fat and skin
- Extra cooking oil or lard if needed
- Sea salt to taste
- Pepper to taste
Instructions
- Preheat oven to 250F and set a wire rack over a baking sheet.
- Using a very sharp knife, cut pork skin and fat into long strips, about 2 inches wide. Score the fat on each strip every two inches. Insert knife carefully between skin and fat on one end of the strip and remove a portion of the fat (you will end up with a thin layer of fat still on the skin and that is fine).
- Once that first part of fat is removed, you can hold the skin in one hand as you slide the knife down the strip to remove the majority of the fat. Again, a little fat still clinging to the skin is okay.
- When the fat has been removed, cut each strip into 2 inch squares and place, fat-side down, on wire rack.
- Bake 3 hours, until skin is completely dried out.
- Meanwhile, if you want to use the pork fat to cook your chicharrones, place it in a large saucepan over medium low heat. Cook gently until most of the fat has liquified, about 2 hours. This is also the same way you can render lard for future cooking use. Use a slotted spoon to remove any remaining solids. Discard (or eat, they taste like bacon and are great on salad!).
- When baking time is up, heat oil/lard to a depth of ⅓ in the pan. Or you can just have a few inches of oil and can cook your pork rinds in batches. Oil should be quite hot but not bubbling.
- Add pork rinds and cook until they bubble and puff up, about 3 to 5 minutes. Remove and drain on a paper towel-lined plate. Sprinkle immediately with salt and pepper.
